Astro25 Series Radios

Motorola Astro25 Series

Market	Public Safety
Release Date	2002
EOL Date	2013
Supported Features	Conventional Analog Conventional P25 Motorola Type II Trunking P25 Phase 1 Trunking

The Astro25 series of radios are public-safety and commercial radios capable of digital P25 conventional and trunking operation. The series was introduced in 2002, and was declared end-of-life in 2013, with depot services continuing until 2018.

Models in Line

Portable Radios

• XTS1500
• XTS2500
• XTS4000
• XTS5000

Mobile Radios

• Astro Spectra Plus
• XTL1500/2500/5000

Features

Flashport Options

Pulled from akardam.net

Flashcode	Description
Q806	Astro IMBE Digital Operation
H14	Enhanced Digital ID Display
Q52	Federal Government FPP
H869	Hardware Multikey Encryption
Q498	Hardware Multikey Encryption with OTAR
H43	Trunked Remote Monitor / Radio Trace
H46	Trunked One Touch Status Message
Q507	12.5kHz FCC Mandate
G996	Over the Air Provisioning
H35	Conventional Systems Operation
H02	Encrypted Tactical Inhibit
H37	Smartnet Systems Operation
H38	SmartZone Systems Operation
G857	FDNY Emergency RX/TX Tone Set
Q369	Inter-system Roaming RSSI
H04	Conventional Tactical Rekey
H345	Astro25 Radio Authentication
Q352	User-definable Soft ID
Q947	APCO Packet Data Interface
Q241	Analog-only Operation
Q53	FCC FPP / Radio Cloning
Q387	Conventional Voting Scan
Q173	SmartZone Omnilink Multizone Operation
Q182	Enhanced Radio Control Protocol
Q361	Astro25 9600baud Trunking
Q445	Fireground Accountability Software
Q446	Fireground Voice/Channel Announcement
Q667	ADP Software Encryption

AN vs BN Radios

Several radios in the Astro25 line are considered "AN" or "4-meg" radios and contain a smaller flash rom chip (4 megabyte vs 8 megabyte) and are more limited in firmware and feature support. Earlier models of the XTS2500 and the Astro Spectra Plus are considered AN radios and are limited to the firmware version specified below.

Firmware

The latest firmware (as of 12/21/2016) is R20.50.08 for 8-meg BN radios and R09.00.41 for 4-meg AN radios.

Software

Astro25 radios program using the Astro25 Portable and Mobile CPS Packages. The portable version of CPS supports the XTS2500, XTS4000, and XTS5000. Astro25 Mobile CPS supports the Astro Spectra Plus, XTL1500, XTL2500, and XTL5000.

Amateur Use & Bandsplits

If you have a radio whose bandsplit is outside the amateur bands (a UHF-R2 "S"-split radio for the 450-520 MHz band would be an example) you must modify the CPS executable to allow the software to accept frequencies which are out of band for the model. This is done using the Hex-edit Method which works for many CPS distributions, and detailed information can be found on the information page.

All Astro25 radios excluding the Astro Spectra Plus will tune to all frequencies in the amateur bands without issues. The Astro Spectra Plus VCO will not lock on some frequencies far from its rated band and requires a hardware mod to allow it to lock properly at these frequencies.

Single-Zone FPP Setup

Contrary to other reports, it is possible to set up a radio running BN firmware (R10+) for only a single zone of FPP channels, as opposed to 16 zones with 16 channels each. The way to do this is not immediately obvious however, as it may seem like all zones are locked as FPP only. The "gotcha" here is that any FPP zone must be preceded by only other FPP zones. I don't know why Motorola decided to do it this way, but you can't just take any zone in the middle of the codeplug and make it FPP or non-FPP.

Starting with a codeplug that has all 16 zones set up for FPP (meaning you also have 128 personalities - yikes), the procedure to get to a single FPP zone is as follows:

1. Start from zone 16. You should be able to uncheck the "FPP Zone" field. Once you acknowledge the warnings and this is done, the 16 personalities assigned to that zone should be deleted and the codeplug structure will have been reopened.
2. Now you should be able to delete zone 16.
3. Follow the above procedure for the remaining 14 zones (zones 2-15)
4. You should be left with a single FPP zone and 16 un-deletable conventional personalities. Configure these however you like per your FPP preference.

15+1 Trunking Scan

For Astro25 CPS R20.00 and R20.01

CPS	Hex Offset	Original Value	New Value
Portable	0x009301A1	0A	0F
Mobile	0x009E4D51	0A	0F

Make these changes to the PatMob or PatPort executable files using your favorite hex editor.

Astro25 Tuner Virtual Com Ports

Astro25 Tuner is known to have issues with reading & writing with higher COM port numbers. Ports above 20 appear to cause issues and give errors such as "Read Radio Failed." If you encounter issues, try lowering the com port number of your virtual com port.